新型CF x 锂原电池自放电率的比较研究及其应用建议

doi:10.19799/j.cnki.2095-4239.2024.0922

储能科学与技术 ›› 2024, Vol. 13 ›› Issue (11): 3742-3753.doi: 10.19799/j.cnki.2095-4239.2024.0922

新型CF _x 锂原电池自放电率的比较研究及其应用建议

杨微¹(), 李治国¹, 赖彩婷¹(), 赵瑞瑞¹, 李瑀²(), 周盈科³, 黄依玲⁴, 朱立才⁴, 封伟², 王文龙⁵, 袁中直⁴()

^1.惠州亿纬锂能股份有限公司，广东惠州 516006
^2.天津大学材料科学与工程学院，天津 300072
^3.武汉科技大学省部共建耐火材料与冶金国家重点实验室，湖北武汉 430081
^4.华南师范大学化学学院，广东广州 510006
^5.中国科学院物理研究所，北京凝聚态物理国家研究;中心，北京 100190

收稿日期:2024-09-30 修回日期:2024-10-14 出版日期:2024-11-28 发布日期:2024-11-27
通讯作者: 赖彩婷,李瑀,袁中直 E-mail:085265@evebattery.com;caitinglai1991@163.com;2022500016@buct.edu.cn;yuanzz@scnu.edu.cn
作者简介:杨微（1995—），女，硕士，研究方向为锂原电池研发，E-mail：085265@evebattery.com；

Comparative study on self-discharge rate of new CF _x lithium primary batteries and recommendations for their use

Wei YANG¹(), Zhiguo LI¹, Caiting LAI¹(), Ruirui ZHAO¹, Yu LI²(), Yingke ZHOU³, Yiling HUANG⁴, Licai ZHU⁴, Wei FENG², Wenlong WANG⁵, Zhongzhi YUAN⁴()

^1.EVE Energy Co. Ltd, Huizhou 516006, Guangdong, China
^2.School of Materials Science and Engineering, Tianjin University, Tianjin 300072, China
^3.The State Key Laboratory of Refractories and Metallurgy, Wuhan University of Science and Technology, Wuhan 430081, Hubei, China
^4.School of Chemistry, South China Normal University, Guangzhou 510006, Guangdong, China
^5.Institute of Physics, Chinese Academy of Sciences, Beijing 100190, China

Received:2024-09-30 Revised:2024-10-14 Online:2024-11-28 Published:2024-11-27
Contact: Caiting LAI, Yu LI, Zhongzhi YUAN E-mail:085265@evebattery.com;caitinglai1991@163.com;2022500016@buct.edu.cn;yuanzz@scnu.edu.cn

摘要/Abstract

摘要：

新型高比能氟化碳(CF _x )材料不断涌现，使Li/CF _x 原电池的比能量/比功率特性持续提升，特别是功率型Li/CF _x 电池已开始用于小型商业化动力系统中，可能成为比能量最高的动力型锂原电池。但不同类型CF _x 材料制备的Li/CF _x 锂原电池的自放电情况尚缺乏比较研究。本文选择4种典型的新型CF _x 材料，根据其应用目标分为能量型和功率型材料，其中2种能量型CF _x 的F/C比接近1，具有更稳定而饱和的C—F化学键，而2种功率型CF _x 材料F/C比略低，离子型C—F键更多，具有更好的导电性和更好的倍率性能。通过工业化设备工艺制备成的BR18650型Li/CF _x 原电池经55 ℃高温储存后，无论是否放电过，能量型电池的自放电率几乎为0，具有长寿命货架储存特性；而功率型电池55 ℃储存后，放电深度(DOD)越高的电池的内阻越大、自放电率也越大，锂原电池常用的预放电处理工艺会导致功率型电池的自放电率上升，意味着功率型电池一旦预放电激活后就应立即投入使用。功率型电池间歇式使用会导致其自放电率增大和内阻增加，原因可能是松散LiF保护膜的破坏造成新鲜CF _x 界面暴露于电解液中继续反应，但能量型CF _x 材料因其具有更多稳定的饱和C—F共价键而影响较小。

关键词: 锂/氟化碳电池, 原电池, 自放电率

Abstract:

The emergence of new high specific energy fluorinated carbon (CF _x ) materials has continuously improved the specific energy/specific power characteristics of Li/CF _x primary batteries, especially the power type Li/CF _x batteries have begun to be used in small commercial power systems and may become the power type lithium primary batteries with the highest specific energy. However, there is a lack of comparative study on the self-discharge of Li/CF _x lithium primary batteries prepared from different types of CF _x materials. This article selects four typical novel CF _x materials that are divided into energy type and power type materials according to their applications, among which two energy type CF _x materials have F/C ratios close to 1 and more stable and saturated C－F chemical bonds, while two power type CF _x materials have lower F/C ratios and more ionic C－F bonds, resulting in better conductivity and rate performance. After being stored at a high temperature of 55 ℃, the self-discharge rate of the industrially prepared BR18650 Li/CF _x battery, regardless of whether it has been discharged or not, is almost zero, making it suitable for long-life shelf storage. However, for power batteries stored at 55 ℃, the higher the depth of discharge (DOD), the greater the internal resistance and self-discharge rate of the battery. The pre-discharge treatment that is commonly used in lithium primary battery industry can lead to an increase in the self-discharge rate of power type batteries, which means that power type batteries should be put into use immediately after pre-discharge activation. Intermittent use of power type batteries can lead to an increase in their self-discharge rate and internal resistance, which may be due to the damage of the loose LiF protective film causing the fresh CF _x interface to be exposed to the electrolyte and continuous reaction, but the energy type CF _x material has less impact due to its more stable saturated C－F covalent bonds.

Key words: lithium/carbon fluoride battery, primary battery, self-discharge rate

中图分类号:

TM 911

杨微, 李治国, 赖彩婷, 赵瑞瑞, 李瑀, 周盈科, 黄依玲, 朱立才, 封伟, 王文龙, 袁中直. 新型CF _x 锂原电池自放电率的比较研究及其应用建议[J]. 储能科学与技术, 2024, 13(11): 3742-3753.

Wei YANG, Zhiguo LI, Caiting LAI, Ruirui ZHAO, Yu LI, Yingke ZHOU, Yiling HUANG, Licai ZHU, Wei FENG, Wenlong WANG, Zhongzhi YUAN. Comparative study on self-discharge rate of new CF _x lithium primary batteries and recommendations for their use[J]. Energy Storage Science and Technology, 2024, 13(11): 3742-3753.

图/表 14

表1

图1

图2

图3

表2

图4

表3

图5

表4

图6

表5

图7

图8

表6

参考文献 29

1	ZHANG S X, KONG L C, LI Y, et al. Fundamentals of Li/CFx battery design and application[J]. Energy & Environmental Science, 2023, 16(5): 1907-1942. DOI: 10.1039/D2EE04179K.
2	ZHU H J, GAVRIL M, FENG L, et al. Li/CFx medical battery development[J]. ECS Transactions, 2008, 11(32): 11-17. DOI: 10.1149/1.2992489.
3	YANG W J, DAI Y, CAI S D, et al. Graphene/Au composite paper as flexible current collector to improve electrochemical performances of CFx cathode[J]. Journal of Power Sources, 2014, 255: 37-42. DOI: 10.1016/j.jpowsour.2013.12.122.
4	YAN K, ZOU Y, BAO L X, et al. Fluorinated N,P co-doped biomass carbon with high-rate performance as cathode material for lithium/fluorinated carbon battery[J]. Rare Metals, 2024. DOI: 10.1007/s12598-024-02894-4.
5	ZHANG Q, D'ASTORG S, XIAO P, et al. Carbon-coated fluorinated graphite for high energy and high power densities primary lithium batteries[J]. Journal of Power Sources, 2010, 195(9): 2914-2917. DOI: 10.1016/j.jpowsour.2009.10.096.
6	LUO Z Y, LUO S, YANG M, et al. Revealing the mechano-electrochemical coupling behavior and discharge mechanism of fluorinated carbon cathodes toward high-power lithium primary batteries[J]. Small, 2024, 20(7): 2305980. DOI: 10.1002/smll.202305980.
7	GUÉRIN K, DUBOIS M, HOUDAYER A, et al. Applicative performances of fluorinated carbons through fluorination routes: A review[J]. Journal of Fluorine Chemistry, 2012, 134: 11-17. DOI: 10.1016/j.jfluchem.2011.06.013.
8	JIANG S B, HUANG P, LU J C, et al. The electrochemical performance of fluorinated ketjenblack as a cathode for lithium/fluorinated carbon batteries[J]. RSC Advances, 2021, 11(41): 25461-25470. DOI: 10.1039/d1ra03873g.
9	PENG C, LI Y, YAO F N, et al. Ultrahigh-energy-density fluorinated calcinated macadamia nut shell cathodes for lithium/fluorinated carbon batteries[J]. Carbon, 2019, 153: 783-791. DOI: 10.1016/j.carbon.2019.07.065.
10	KONG L C, LI Y, PENG C, et al. Defective nano-structure regulating C－F bond for lithium/fluorinated carbon batteries with dual high-performance[J]. Nano Energy, 2022, 104: 107905. DOI: 10.1016/j.nanoen.2022.107905.
11	LAM P, YAZAMI R. Physical characteristics and rate performance of (CFx)n (0.33<x<0.66) in lithium batteries[J]. Journal of Power Sources, 2006, 153(2): 354-359. DOI: 10.1016/j.jpowsour. 2005.05.022.
12	MA J, LIU Y F, PENG Y, et al. UV-radiation inducing strategy to tune fluorinated carbon bonds delivering the high-rate Li/CFx primary batteries[J]. Composites Part B: Engineering, 2022, 230: 109494. DOI: 10.1016/j.compositesb.2021.109494.
13	DAI Y, FANG Y, CAI S D, et al. Surface modified pinecone shaped hierarchical structure fluorinated mesocarbon microbeads for ultrafast discharge and improved electrochemical performances[J]. Journal of the Electrochemical Society, 2016, 164(2): A1-A7. DOI: 10.1149/2.0451614jes.
14	DAI Y, CAI S D, WU L J, et al. Surface modified CFx cathode material for ultrafast discharge and high energy density[J]. Journal of Materials Chemistry A, 2014, 2(48): 20896-20901. DOI: 10.1039/C4TA05492J.
15	YIN Y J, HOLOUBEK J, LIU A, et al. Ultralow-temperature Li/CFx batteries enabled by fast-transport and anion-pairing liquefied gas electrolytes[J]. Advanced Materials, 2023, 35(3): e2207932. DOI: 10.1002/adma.202207932.
16	WANG X X, SONG Z Y, WU H, et al. Anion donicity of liquid electrolytes for lithium carbon fluoride batteries[J]. Angewandte Chemie International Edition, 2022, 61(47): e202211623. DOI: 10.1002/anie.202211623.
17	YU J, WANG D, WANG G, et al. Breaking the electronic conductivity bottleneck of manganese oxide family for high-power fluorinated graphite composite cathode by ligand-field high-dimensional constraining strategy[J]. Advanced Materials, 2023, 35(8): 2209210.
18	LI L Y, WU R Z, MA H C, et al. Toward the high-performance lithium primary batteries by chemically modified fluorinate carbon with δ-MnO₂[J]. Small, 2023, 19(26): 2300762. DOI: 10.1002/smll.202300762.
19	LI Y Y, WU X Z, LIU C, et al. Fluorinated multi-walled carbon nanotubes as cathode materials of lithium and sodium primary batteries: Effect of graphitization of carbon nanotubes[J]. Journal of Materials Chemistry A, 2019, 7(12): 7128-7137. DOI: 10.1039/c8ta12074a.
20	阳晓霞, 段征, 金晶龙, 等. 高比能氟化碳材料及Li/CFx电池的特性研究[J]. 电源技术, 2018, 42(8): 1161-1162, 1170. DOI: 10.3969/j.issn.1002-087X.2018.08.021.
	YANG X X, DUAN Z, JIN J L, et al. Performance research of polycarbon mono-fluoride and Li/CFx cell[J]. Chinese Journal of Power Sources, 2018, 42(8): 1161-1162, 1170. DOI: 10.3969/j.issn.1002-087X.2018.08.021.
21	卢立丽, 王松蕊. 锂氟化碳电池放电热效应的模拟研究[J]. 电源技术, 2016, 40(5): 1098-1102. DOI: 10.3969/j.issn.1002-087X.2016.05.048.
	LU L L, WANG S R. Studies on thermal effects during discharging of lithium carbon fluoride cells by simulation[J]. Chinese Journal of Power Sources, 2016, 40(5): 1098-1102. DOI: 10.3969/j.issn.1002-087X.2016.05.048.
22	LIU W, YAN T F, GUO R, et al. Analysis of electrochemical performance of lithium carbon fluorides primary batteries after storage[J]. Journal of Materiomics, 2021, 7(6): 1225-1232. DOI: 10.1016/j.jmat.2021.02.010.
23	ZHOU R X, LI Y, FENG Y Y, et al. The electrochemical performances of fluorinated hard carbon as the cathode of lithium primary batteries[J]. Composites Communications, 2020, 21: 100396. DOI: 10.1016/j.coco.2020.100396.
24	GONG P W, WANG Z F, WANG J Q, et al. One-pot sonochemical preparation of fluorographene and selective tuning of its fluorine coverage[J]. Journal of Materials Chemistry, 2012, 22(33): 16950-16956. DOI: 10.1039/C2JM32294C.
25	张红梅, 甘潦, 王开琼, 等. 纳米Ag改性方式对锂氟化碳电池性能的影响[J]. 电源技术, 2023, 47(9): 1164-1168. DOI: 10.3969/j.issn.1002-087X.2023.09.013.
	ZHANG H M, GAN L, WANG K Q, et al. Effect of nano-Ag modification methods on performance of lithium fluoride carbon batteries[J]. Chinese Journal of Power Sources, 2023, 47(9): 1164-1168. DOI: 10.3969/j.issn.1002-087X.2023.09.013.
26	LIU W, MA S, LI Y, et al. Electrochemical impedance spectroscopy analysis for lithium carbon fluorides primary battery[J]. Journal of Energy Storage, 2023, 68: 107699. DOI: 10.1016/j.est.2023.107699.
27	ZHONG G M, CHEN H X, CHENG Y, et al. Insights into the lithiation mechanism of CFx by a joint high-resolution ¹⁹F NMR, in situ TEM and ⁷Li NMR approach[J]. Journal of Materials Chemistry A, 2019, 7(34): 19793-19799. DOI: 10.1039/C9TA06800G.
28	LI Q, XUE W R, SUN X R, et al. Gaseous electrolyte additive BF₃ for high-power Li/CFx primary batteries[J]. Energy Storage Materials, 2021, 38: 482-488. DOI: 10.1016/j.ensm.2021.03.024.
29	SROUT M, CARBONI M, GONZALEZ J A, et al. Insights into the importance of native passivation layer and interface reactivity of metallic lithium by electrochemical impedance spectroscopy[J]. Small, 2023, 19(7): 2206252. DOI: 10.1002/smll.202206252.

材料	F/C	粒径/μm				杂质元素含量/ppm							振实密度/(g/cm³)	比容量/(mAh/g)
材料	F/C	D₁₀	D₅₀	D₉₀	D_max	Fe	Cu	Ni	Zn	Na	Mg	Cr	振实密度/(g/cm³)	比容量/(mAh/g)
CF01	0.98	3.000	8.250	17.470	35.566	4.43	ND	6.068	ND	1.41	0.03	2.41	0.9517	849.66
CF02	0.94	2.265	5.946	12.735	25.178	80.81	0.217	84.69	ND	14.87	ND	9.313	0.9616	814.42
CF03	0.88	2.919	5.804	10.626	17.825	20.09	1.784	20.78	3.149	ND	0.263	4.611	0.7926	756.13
CF04	0.87	1.984	10.515	22.657	39.905	19.34	0.678	15.65	2.11	ND	0.225	1.694	1.0045	750.28

CF _x 样品	比表面积/(m²/g)	孔体积/(cm³/g)
CF01	226.04	0.1178
CF02	312.32	0.1693
CF03	440.67	0.3170
CF04	283.84	0.1612

	C 1s/eV					表面元素含量/%
样本	284.73	287.17	289.10	290.00	291.92	C	F
	C1(C=C<)	C2(CF-C<)	C3[FC(C3)]-Semi-ionic	C3[FC(C3)]-Covalent	C4[F2C(CF)2]	C	F
CF01	8.03	3.05	1.92	75.50	11.50	45.24	54.76
CF02	6.82	9.00	2.27	64.71	17.00	45.00	55.00
CF03	10.20	20.68	3.70	50.89	14.53	46.79	53.21
CF04	6.81	16.67	2.70	55.00	18.82	50.10	49.90

电池	55℃存储	放电倍率	放电截止2 V的容量保持率/%
电池	55℃存储	放电倍率	0% DOD	10% DOD	30% DOD	50% DOD
Li/CF01	30 d	0.01C	99.59	99.72	101.17	100.42
	60 d		99.55	99.88	101.36	100.14
	90 d		99.64	99.94	100.71	100.40

Li/CF02	30 d	0.01C	99.41	100.10	100.21	100.78
	60 d		99.44	99.59	99.47	99.35
	90 d		99.52	99.62	99.83	99.27

Li/CF03	30 d	0.5C	96.76	99.20	99.42	76.20
	60 d		96.20	97.30	95.60	75.63
	90 d		95.50	92.59	89.91	66.73

Li/CF04	30 d	0.5C	98.63	98.47	97.86	98.23
	60 d		98.67	98.18	97.02	97.92
	90 d		98.35	96.95	96.65	94.71

方案	存储时间	截止2 V材料发挥率/%	截止2 V容量保持率/%	自放电率/%
CF03(-)	0 d	77.09
CF03(-)	30 d	76.19	99.43	0.57

CF03(+)	0 d	72.94
CF03(+)	30 d	70.33	96.76	3.42

新型CF _x 锂原电池自放电率的比较研究及其应用建议

Comparative study on self-discharge rate of new CF _x lithium primary batteries and recommendations for their use

RichHTML

PDF

可视化

摘要/Abstract

引用本文

使用本文

图/表 14

参考文献 29

相关文章 1

编辑推荐

Metrics

本文评价

新型CF x 锂原电池自放电率的比较研究及其应用建议

Comparative study on self-discharge rate of new CF x lithium primary batteries and recommendations for their use

RichHTML

PDF

可视化

摘要/Abstract

引用本文

使用本文

图/表 14

参考文献 29

相关文章 1

编辑推荐

Metrics

本文评价

新型CF _x 锂原电池自放电率的比较研究及其应用建议

Comparative study on self-discharge rate of new CF _x lithium primary batteries and recommendations for their use