Research on disturbance analysis and detection method for the magnetically suspended flywheel-based PMSM system

doi:10.12028/j.issn.2095-4239.2017.0157

Abstract

Abstract: This paper presents the modeling and characteristic analysis of the unknown disturbances for the flywheel energy storage system, considering the property of the three-phase permanent magnet synchronous motor. Firstly, the rotor dynamics mode under the circumstance of the dynamical base is established, and based on this, the model and property of the multi-source disturbances are given in detail. A status detection system is designed and accomplished to gain the essential input parameters for the disturbance. Then, the real-time speed, magnetically bias force and base vibration information can be obtained for the flywheel energy storage system. Finally, the experimental equipment of the magnetically suspended flywheel energy storage system is proposed with the flywheel parameters, which can be used appropriately to demonstrate the disturbance property and its depressing strategy.

Key words: magnetically suspended flywheel energy storage system, permanent magnet synchronous motor, disturbance status detection system

CLC Number:

TM341

LI Shusheng, FU Yongling, LIU Ping, WANG Zhiqiang. Research on disturbance analysis and detection method for the magnetically suspended flywheel-based PMSM system[J]. Energy Storage Science and Technology, 2018, 7(5): 794-803.

References

[1] 戴兴建, 邓占峰, 刘刚, 等. 大容量先进飞轮储能电源技术发展状况[J]. 电工技术学报, 2011, 26(7):133-140. DAI Xingjian, DENG Zhanfeng, LIU Gang, et al. Review on advanced flywheel energy storage system with large scale[J]. Transactions of China Electrotechnical Society, 2011, 26(7):133-140.
[2] 戴兴建, 张小章, 姜新建, 等. 清华大学飞轮储能技术研究概况[J]. 储能科学与技术, 2012, 1(1):64-68. DAI Xingjian, ZHANG Xiaozhang, JIANG Xinjian, et al. Flywheel energy storage technology in Tsinghua University[J]. Energy Storage Science and Technology, 2012, 1(1):64-68.
[3] 王传东. 飞轮电池发展研究[J]. 电源技术, 2014, 38(7):1402-1403. WANG Chuandong. Development of flywheel battery[J]. Power Technology, 2014, 38(7):1402-1403.
[4] 陈亚爱, 甘时霖, 周京华, 等. 飞轮储能技术[J]. 电源技术, 2016, 40(8):1718-1721. CHEN Yaai, GAN Shilin, ZHOU Jinghua. Energy storage technology of flywheel[J]. Power Technology, 2016, 40(8):1718-1721.
[5] 刘付成, 李结冻, 李延宝, 等. 磁悬浮储能飞轮技术研究及应用示范[J]. 上海节能, 2017(2):80-84. LIU Fucheng, LI Jiedong, LI Yanbao, et al. Research and application demonstration of maglev energy storage flywheel technology[J]. Shanghai Energy Conservation, 2017(2):80-84.
[6] 毕文俊. 基于飞轮储能的地铁再生制动能量利用研究[D]. 成都:西南交通大学, 2016. BI Wenjun. The study of subway braking energy utilization based on flywheel energy storage[D]. Chengdu:Southwest Jiaotong University, 2016.
[7] 李树胜, 付永领, 刘平, 等. 磁悬浮飞轮储能UPS系统集成应用及充放电控制方法研究[J]. 中国电机工程学报, 2017, 37(1):170-176. LI Shusheng, FU Yongling, LIU ping, et al. Research on integrated application and charging-discharging control method for the magnetically suspended flywheel storage-based UPS system[J]. Proceedings of the CSEE, 2017, 37(1):170-176.
[8] 张超平, 戴兴建, 苏安平, 等. 石油钻机动力系统飞轮储能调峰试验研究[J]. 石油机械, 2013, 41(5):3-6. ZHAO Chaoping, DAI Xingjian, SU Anping, et al. Experimental study of flywheel energy storage and peak regulation of rig power system[J]. China Peroleum Machinery, 2013, 41(5):3-6.
[9] 魏鲲鹏, 汪勇, 戴兴建. 飞轮储能系统在风力发电中应用研究进展[J]. 储能科学与技术, 2015, 4(2):141-146. WEI Kunpeng, WANG Yong, DAI Xingjian. Review of flywheel energy storage system for wind power applications[J]. Energy Storage Science and Technology, 2015, 4(2):141-146.
[10] 李然. 飞轮储能技术在电力系统中的应用和推广[J]. 电气时代, 2017:40-42. LI Ran. Application of flywheel energy storage system in power system[J]. The Age of Electricity, 2017:40-42.
[11] CALNETIX TECHNOLOGIES. Vycon direct connect kinetic energy storage systems[EB/OL]. USA, 2016. http://www.Calnetix.com/.
[12] ACTIVE POWER. Clean source xt ups single module systems[EB/OL]. USA, 2017. http://www.activepower.com/en-US/documents/3974/cleansource-xt250-ups-en.pdf.
[13] HEADQUARTERS. Piller power systems[EB/OL]. Germany, 2017. http://www.piller.com/en-GB/documents/552/apostar-static-ups-brochure-en.pdf.
[14] 鲍海静, 梁培鑫, 柴凤. 飞轮储能用高速永磁同步电机技术综述[J]. 微电机, 2014, 47(2):64-72. BAO Haijing, LIANG Peixin, CHAI Feng. Key technology of high speed permanent magnet synchronous motors for FESS[J]. Micromotors, 2014, 47(2):64-72.
[15] 邢向上, 姜新建. 飞轮储能系统电机及其控制器概述[J]. 储能科学与技术, 2015, 4(2):147-152. XING Xiangshang, JIANG Xinjian. Introduction to motors and controllers of flywheel energy storage systems[J]. Energy Storage Science and Technology, 2015, 4(2):147-152.
[16] 陆婋泉, 林鹤云, 韩俊林. 永磁同步电机的扰动观测器无位置传感器控制[J]. 中国电机工程学报, 2016, 36(5):1387-1393. LU Xiaoquan, LIN Heyun, HAN Junlin. Position sensorless control of permanent magnet synchronous machine[J]. Proceedings of the CSEE, 2016, 36(5):1387-1393
[17] ZHAO Jing, GU Zhongxin, LI Bin, et al. Research on the torque and back EMF performance of a high speed PMSM used for flywheel energy storage[J]. Energies, 2017, 8(4):2867-2888.
[18] WANG Gengji, WANG Ping. Rotor loss analysis of PMSM in flywheel energy storage system as uninterruptable power supply[J]. IEEE Transactions on Applied Superconductivity, 2017, 26(7):1-7.
[19] 薛小川, 王志强. 磁悬浮储能飞轮振动状态研究[J]. 自动化仪表, 2017, 38(7):89-94. XUE Xiaochuan, WANG Zhiqiang. Study on the vibration condition monitoring for magnetic levitation energy storage flywheel[J]. Process Automation Instrumentation, 2017, 38(7):89-94.
[20] 张激扬, 刘虎, 王虹, 等.飞轮扰振特性及振动控制方法[J]. 空间控制技术与应用, 2014, 40(5):18-25. ZHANG Jiyang, LIU Hu, WANG Hong, et al. Microvibration characteristics of flywheels and its vibration control approaches[J]. Aerospace Control and Application, 2014, 40(5):18-25.
[21] LI Lin, TAN Luyang, KONG Lin, et al. Flywheel micro-vibration characters of a high resolution optical satellite[J]. Journal of Vibroengineering, 2017, 19(6):3981-3993.
[22] 崔淑梅, 匡志, 杜博超. 基于自抗扰控制原理的全电飞机用永磁同步电机转速闭环控制[J]. 电工技术学报, 2017, 32(s1):107-115. CUI Shumei, KUANG Zhi, DU Bochao. Speed closed-loop control of permanent magnet synchronous motor for all-electric aircraft applications based on active disturbance rejection controller[J]. Transactions of China Electrotechnical Society, 2017, 32(s1):107-115.
[23] 梁明亮, 陈志红, 孙晶晶. 基于ESO的永磁同步电机位置伺服系统滑模变结构反步控制[J]. 科技通报, 2017, 33(5):72-76. LIANG Mingliang, CHEN Zhihong, SUN Jingjing. Sliding mode variable structure backstepping control of permanent magnet synchronous motor position servo system based on eso[J]. Bulletin of Science and Technology, 2017, 33(5):72-76.
[24] WU Yunjie, GUO Fei. Adaptive disturbance compensation finite control set optimal control for PMSM systems based on sliding mode extended state observer[J]. Mechanical Systems and Signal Processing, 2018, 98:402-414.
[25] 陈荣. 永磁同步电机控制系统[M]. 北京:中国水利水电出版社, 2009. CHEN Rong. Permanent magnet synchronous motor control system[M]. Beijing:China Waterpower Press, 2009.
[26] 于波, 陈云相, 郭秀忠. 惯性技术[M]. 北京:北京航空航天大学出版社, 1994. YU Bo, CHEN Yunxiang, Guo Xiuzhong. Inertial technology[M]. Beijing:Beihang University, 1994.
[27] 闫永蚕, 汤洲, 高楠, 等. 基于空气动力学的高速列车造型设计研究进展[J]. 机械设计, 2017, 34(6):105-112. YAN Yongcan, TANG Zhou, GAO Nan, et al. Research progress on modeling design of high-speed train based on aerodynamics[J]. Journal of Machine Design, 2017, 34(6):105-112.
[28] 解瑞雪. 车辆尾部多参数空气动力学分析及优化设计[J]. 上海电机学院学报, 2017, 20(3):125-131. XIE Ruixue. Multi-parameter aerodynamic analysis andoptimized[J]. Journal of Shanghai Dianji University, 2017, 20(3):125-131.