多元包覆石墨复合负极材料的低温电化学储锂性能研究

doi:10.19799/j.cnki.2095-4239.2024.0408

储能科学与技术 ›› 2024, Vol. 13 ›› Issue (7): 2116-2123.doi: 10.19799/j.cnki.2095-4239.2024.0408

多元包覆石墨复合负极材料的低温电化学储锂性能研究

肖鹏飞(), 梅琳(), 陈立宝()

中南大学粉末冶金国家重点实验室，湖南长沙 410083

收稿日期:2024-05-07 修回日期:2024-06-03 出版日期:2024-07-28 发布日期:2024-07-23
通讯作者: 梅琳,陈立宝 E-mail:761758726@qq.com;meilin@csu.edu.cn;lbchen@csu.edu.cn
作者简介:肖鹏飞（1998—），男，硕士研究生，研究方向为新能源材料，E-mail：761758726@qq.com；
基金资助:
国家自然科学基金(92372117);湖南省自然科学基金(2022JJ20068);中南大学创新驱动基金(2023CXQD024)

Multicomponent-coated graphite composite anodes for low-temperature electrochemical energy storage

Pengfei XIAO(), Lin MEI(), Libao CHEN()

State Key Laboratory of Powder Metallurgy, Central South University, Changsha 410083, Hunan, China

Received:2024-05-07 Revised:2024-06-03 Online:2024-07-28 Published:2024-07-23
Contact: Lin MEI, Libao CHEN E-mail:761758726@qq.com;meilin@csu.edu.cn;lbchen@csu.edu.cn

摘要/Abstract

摘要：

新能源技术的快速发展对锂离子电池在极端环境的使用提出了更高的要求。目前锂离子电池的低温性能主要受限于石墨负极界面阻抗，导致锂离子的嵌入和脱嵌过程受阻。本文通过液相法将沥青衍生碳和氧化铌颗粒协同包覆在石墨颗粒表面，制备了无定形碳/氧化铌多元包覆石墨复合负极材料(C/Nb-Gr)。调控复合材料制备方法和包覆比例，测试复合负极材料的常温和低温循环性能，对比不同实验方法对复合负极材料电化学储锂性能的影响。结果表明，无定形碳/氧化铌包覆石墨复合负极材料的倍率性能和低温储锂性能有所提升。在室温5C电流密度充放电时，C/Nb-Gr-10材料具有156.18 mAh/g的比容量；在-20 ℃条件下，C/Nb-Gr-10材料放电比容量为204.60 mAh/g，达到室温放电比容量55.7%的保持率。

关键词: 石墨负极, 表面改性, 低温储能, 锂离子电池

Abstract:

The rapid development of new energy technologies has demanded higher requirements for the application of lithium-ion batteries (LIBs) for operation at low temperatures. The poor surface dynamics of graphite anodes is one of the main issues limiting the low-temperature performance of LIBs. In this study, amorphous carbon/niobium oxide multicomponent-coated graphite composite materials (C/Nb-Gr) were synthesized using a liquid-phase method. The optimal C/Nb-Gr ratio was determined by adjusting the preparation method and coating ratio of multicomponent materials. The crystal structure, morphology, and elemental distribution of C/Nb-Gr were characterized using X-ray diffraction, scanning electron microscopy, transmission electron microscopy, and energy-dispersive X-ray spectroscopy. Furthermore, its electrochemical performance at high rates and low temperatures was evaluated using cyclic voltammetry, electrochemical impedance spectroscopy, and charge/discharge cycling. The graphite electrode coated with amorphous carbon/niobium oxide exhibited improved performance at high rates and low temperatures. When charged/discharged at a high current density of 5C at room temperature, C/Nb-Gr-10 demonstrated a reversible specific capacity of 156.18 mAh/g. Under low-temperature conditions (-20 ℃) at a current density of 0.1C, the discharge specific capacity of C/Nb-Gr-10 was 204.60 mAh/g, representing 55.7% of its room-temperature discharge specific capacity.

Key words: graphite anodes, surface modification, low-temperature energy storage, lithium-ion batteries

中图分类号:

TM 911

肖鹏飞, 梅琳, 陈立宝. 多元包覆石墨复合负极材料的低温电化学储锂性能研究[J]. 储能科学与技术, 2024, 13(7): 2116-2123.

Pengfei XIAO, Lin MEI, Libao CHEN. Multicomponent-coated graphite composite anodes for low-temperature electrochemical energy storage[J]. Energy Storage Science and Technology, 2024, 13(7): 2116-2123.

图/表 7

表1

图1

图2

图3

图4

图5

图6

参考文献 18

1	RUGGERI I, MARTIN J, WOHLFAHRT-MEHRENS M, et al. Interfacial kinetics and low-temperature behavior of spheroidized natural graphite particles as anode for Li-ion batteries[J]. Journal of Solid State Electrochemistry, 2022, 26(1): 73-83. DOI: 10.1007/s10008-021-04974-2.
2	YANG Y S, CHEN Y F, TAN L L, et al. Rechargeable LiNi_0.65Co_0.15Mn_0.2O₂\|\|Graphite batteries operating at -60 ℃[J]. Angewandte Chemie International Edition, 2022, 61(42): DOI: 10.1002/anie.202209619.
3	LI S Q, WANG K, ZHANG G F, et al. Fast charging anode materials for lithium-ion batteries: Current status and perspectives[J]. Advanced Functional Materials, 2022, 32(23): DOI: 10.1002/adfm.202200796.
4	WEN Y, HE K, ZHU Y J, et al. Expanded graphite as superior anode for sodium-ion batteries[J]. Nature Communications, 2014, 5: 4033. DOI: 10.1038/ncomms5033.
5	SHIM J H, LEE S H. Characterization of graphite etched with potassium hydroxide and its application in fast-rechargeable lithium ion batteries[J]. Journal of Power Sources, 2016, 324: 475-483. DOI: 10.1016/j.jpowsour.2016.05.094.
6	GUO B D, LIU Q, CHEN E D, et al. Controllable N-doping of graphene[J]. Nano Letters, 2010, 10(12): 4975-4980. DOI: 10.1021/nl103079j.
7	WANG M M, WANG J R, XIAO J C, et al. Introducing a pseudocapacitive lithium storage mechanism into graphite by defect engineering for fast-charging lithium-ion batteries[J]. ACS Applied Materials & Interfaces, 2022, 14(14): 16279-16288. DOI: 10.1021/acsami.2c02169.
8	CHANG X Q, SUN N, ZHOU H Y, et al. Soft carbon-coated bulk graphite for improved potassium ion storage[J]. Chinese Chemical Letters, 2023, 34(3): 107312. DOI: 10.1016/j.cclet.2022.03.035.
9	LI H Q, ZHOU H S. Enhancing the performances of Li-ion batteries by carbon-coating: Present and future[J]. Chemical Communications, 2012, 48(9): 1201-1217. DOI: 10.1039/c1cc14764a.
10	OKA H, KADOURA H, TAKAHASHI N T, et al. Effect of amorphous carbon coating on the formation of solid electrolyte interphase and electrochemical properties of a graphite electrode[J]. Journal of Power Sources, 2022, 543: DOI: 10.1016/j.jpowsour.2022.231850.
11	LU H Y, CHEN X Y, JIA Y L, et al. Engineering Al₂O₃ atomic layer deposition: Enhanced hard carbon-electrolyte interface towards practical sodium ion batteries[J]. Nano Energy, 2019, 64: DOI: 10.1016/j.nanoen.2019.103903.
12	ZHOU J H, MA K N, LIAN X Y, et al. Eliminating graphite exfoliation with an artificial solid electrolyte interphase for stable lithium-ion batteries[J]. Small, 2022, 18(15): DOI: 10.1002/smll.202107460.
13	ZHANG M, HE Y X, XU H J, et al. Nb₂O₅ nanoparticles embedding in graphite hybrid as a high-rate and long-cycle anode for lithium-ion batteries[J]. Rare Metals, 2022, 41(3): 814-821. DOI: 10.1007/s12598-021-01863-5.
14	LIU W H, WANG X P, LIU J S, et al. Graphite-based composite anodes with C-O-Nb heterointerfaces enable fast lithium storage[J]. ChemSusChem, 2023, 16(10): DOI: 10.1002/cssc.202300067.
15	DU P, FAN X M, ZHANG B, et al. The lithiophobic-to-lithiophilic transition on the graphite towards ultrafast-charging and long-cycling lithium-ion batteries[J]. Energy Storage Materials, 2022, 50: 648-657. DOI: 10.1016/j.ensm.2022.05.056.
16	SONG Z H, LI H, LIU W, et al. Ultrafast and stable Li-(de)intercalation in a large single crystal H-Nb₂O₅ anode via optimizing the homogeneity of electron and ion transport[J]. Advanced Materials, 2020, 32(22): DOI: 10.1002/adma.202001001.
17	LIU Y C, RUSSO P A, MONTORO L A, et al. Recent developments in Nb-based oxides with crystallographic shear structures as anode materials for high-rate lithium-ion energy storage[J]. Battery Energy, 2023, 2(1): DOI: 10.1002/bte2.20220037.
18	CAO D P, YAO Z G, LIU J J, et al. H-Nb₂O₅ wired by tetragonal tungsten bronze related domains as high-rate anode for Li-ion batteries[J]. Energy Storage Materials, 2018, 11: 152-160. DOI: 10.1016/j.ensm.2017.10.005.

[1]	陈国贺, 吕培召, 李孟涵, 饶中浩. 锂离子电池热失控传播特性及其抑制策略研究进展[J]. 储能科学与技术, 2024, 13(7): 2470-2482.
[2]	李昌豪, 汪书苹, 杨献坤, 曾子琪, 周昕玥, 谢佳. 低温型锂离子电池中的非水电解质研究进展[J]. 储能科学与技术, 2024, 13(7): 2286-2299.
[3]	刘承鑫, 李梓衡, 陈泽宇, 李鹏祥, 陶庆一. 储能锂离子电池高温诱发热失控特性研究[J]. 储能科学与技术, 2024, 13(7): 2425-2431.
[4]	陆洋, 闫帅帅, 马骁, 刘誌, 章伟立, 刘凯. 低温锂电池电解液的研究与应用[J]. 储能科学与技术, 2024, 13(7): 2224-2242.
[5]	廖世接, 魏颖, 黄云辉, 胡仁宗, 许恒辉. 间二氟苯稀释剂稳定电极界面助力低温锂金属电池[J]. 储能科学与技术, 2024, 13(7): 2124-2130.
[6]	王美龙, 薛煜瑞, 胡文茜, 杜可遇, 孙瑞涛, 张彬, 尤雅. 低温磷酸铁锂电池用全醚高熵电解液的设计研究[J]. 储能科学与技术, 2024, 13(7): 2131-2140.
[7]	马国政, 陈金伟, 熊兴宇, 杨振忠, 周钢, 胡仁宗. SnSb-Li₄Ti₅O₁₂ 复合负极材料低温高倍率储锂特性研究[J]. 储能科学与技术, 2024, 13(7): 2107-2115.
[8]	王文涛, 魏一凡, 黄鲲, 吕国伟, 张思瑶, 唐昕雅, 陈泽彦, 林清源, 母志鹏, 王昆桦, 才华, 陈军. 低温锂离子电池测试标准及研究进展[J]. 储能科学与技术, 2024, 13(7): 2300-2307.
[9]	李征, 杨振忠, 王琼, 胡仁宗. 基于专利情报分析的锂离子电池用低温电解液的发展现状和研究进展[J]. 储能科学与技术, 2024, 13(7): 2317-2326.
[10]	程广玉, 刘新伟, 刘硕, 顾海涛, 王可. 调控电解液溶剂组分实现LCO/C低温18650电池循环寿命显著提升[J]. 储能科学与技术, 2024, 13(7): 2171-2180.
[11]	李泽珩, 徐磊, 姚雨星, 闫崇, 翟喜民, 郝雪纯, 陈爱兵, 黄佳琦, 别晓非, 孙焕丽, 范丽珍, 张强. 电解液改善锂离子电池低温析锂研究进展[J]. 储能科学与技术, 2024, 13(7): 2192-2205.
[12]	汪书苹, 杨献坤, 李昌豪, 曾子琪, 程宜风, 谢佳. 乙基膦酸二乙酯基阻燃宽温域电解液在锂离子电池中的应用[J]. 储能科学与技术, 2024, 13(7): 2161-2170.
[13]	李晨威, 徐世国, 余海峰, 于松民, 江浩. 镁掺杂改性LiMn_0.5Fe_0.5PO₄/C正极材料与性能研究[J]. 储能科学与技术, 2024, 13(6): 1767-1774.
[14]	孙琦, 彭豪, 孟庆国, 孔德凯, 冯睿. 极限工况下储能电池包热适应性[J]. 储能科学与技术, 2024, 13(6): 2039-2043.
[15]	张玉超, 张凤姣, 娄伟, 昝飞翔, 王琳玲, 盛安旭, 吴晓辉, 陈静. 废旧锂离子电池有价金属资源化利用的转化过程和潜在环境影响[J]. 储能科学与技术, 2024, 13(6): 1861-1870.

多元包覆石墨复合负极材料的低温电化学储锂性能研究

Multicomponent-coated graphite composite anodes for low-temperature electrochemical energy storage

RichHTML

PDF

可视化

摘要/Abstract

引用本文

使用本文

图/表 7

参考文献 18

相关文章 15

编辑推荐

Metrics

本文评价

样品	石墨/%	沥青/%	氧化铌/%
Gr	100	0	0
C-Gr	90	10	0
Nb-Gr	90	0	10
C/Nb-Gr-5	85	10	5
C/Nb-Gr-10	80	10	10
C/Nb-Gr-20	70	10	20